CarburetorHog Wash HW-6 Carburetor / Choke Cleaner
MATERIAL SAFETY DATA SHEET PAGE 1 OF 4
 
COMPANY HERDOR'S INCORPORATED
ADDRESS P.O. BOX 157
CITY MOKENA, IL 60448
PHONE (708) 479 6166
 
=================================================================SECTION 1 
PRODUCT IDENTITY
LABEL NAME HOG WASH AEROSOL
CHEMICAL FAMILY CHOKE AND CARBURETOR CLEANER
FORMULA NUMBER TRADE SECRET
=================================================================SECTION 2 
HAZARDOUS INGREDIENTS
CHEMICAL CAS # TLV
DIACETONE ALCOHOL 123-42-2 50
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SARA 313 AND 40 CFR 372
XYLENES 1330-20-7 100 20-30 %
ETHYL BENZENE 100-41-4 100 2-5 %
ACETONE 67-64-1 1000 20 + %
TOLUOL 108-88-3 100 20 +
METHANOL 67-56-1 200 5 %
==================================================================
SECTION 3 PHYSICAL & CHEMICAL PROPERTIES
 
BOILING POINT 135 o F SPECIFIC GRAVITY 0.85
VAPOR PRESSURE ND PERCENT VOLATILE 90+
SOLUBILITY IN WATER MODERATE
APPEARANCE AND ODOR CLEAR PALE LIQUID, AROMATIC ODOR. 
=================================================================SECTION 4 FIRE 
& EXPLOSIVE HAZARD DATA
 
FLASH POINT -4 o F TCC 
 
FLAMMABILITY LIMITS- UPPER ND LOWER ND
 
EXTINGUISHING MEDIA: CARBON DIOXIDE, FOAM, DRY CHEMICAL
 
SPECIAL FIRE FIGHTING PROCEDURE
RECOMMENDED SELF CONTAINED BREATHING APPARATUS WITH A FULL
FACE PIECE OPERATED IN A PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE AND FULL BODY PROTECTIVE CLOTHING.
WATER MAY BE USED TO KEEP FIRE-EXPOSED CONTAINERS COOL UNTIL
FIRE IS OUT.
UNUSUAL FIRE & EXPLOSIVE HAZARDS AND PHYSICAL HAZARDS.
COMBUSTION CAN PRODUCE NOXIOUS SMOKE & FUMES.
EXPOSING PRODUCT TO INTENSE HEAT CAN CAUSE THE CONTAINERS
TO RUPTURE.
"ESSENTIALLY SIMILAR" TO OSHA FORM. NA = NOT APPLICABLE
NF = NOT FOUND
ND = NOT DETERMINED
 
SECTION 5 REACTIVITY DATA PAGE 2 OF 4
 
 
STABILITY STABLE
 
CONDITIONS TO AVOID FLAME, SPARKS, HIGH ENERGY SOURCE
 
INCOMPATIBILITY STRONG OXIDIZING AGENTS
 
HAZARDOUS DECOMPOSITION PRODUCTS:
COMBUSTION CAN CAUSE OXIDES OF CARBON, INCOMPLETELY
BURNED HYDROCARBON PRODUCTS.
 
HAZARDOUS POLYMERIZATION
WILL NOT OCCUR
 
=================================================================
SECTION 6 HEALTH EFFECTS OF EXPOSURE 
 
EYES FLUSH EYES WITH CLEAR WATER FOR AT
LEAST 15 MINUTES. THIS MATERIAL IS A
SEVERE EYE IRRITANT. SEEK MEDICAL
ATTENTION. 
SKIN REMOVE CONTAMINATED SHOES OR CLOTHING
AND WASH AFFECTED AREAS WITH SOAP AND
WATER. IF IRRITATION OR REDNESS
PERSISTS, SEEK MEDICAL ATTENTION.
 
INGESTION THIS PRODUCT CONTAINS METHANOL. IT IS HIGHLY TOXIC. IF SWALLOWED
SEE A PHYSICIAN IMMEDIATELY.
 
INHALATION IF EXPOSURE SYMPTOMS DEVELOP, REMOVE TO FRESH AIR. SEEK MEDICAL 
ATTENTION
================================================================= 
HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: EYES, SKIN, INGESTION, INHALATION
 
PUBLISHED EXPOSURE LIMITS SEE SECTION 2
LISTED AS CARCINOGEN NO
=================================================================EFFECTS OF 
OVEREXPOSURE (INCLUDING ANY MEDICAL CONDITIONS THAT
ARE GENERALLY RECOGNIZED AS BEING AGGRAVATED BY EXPOSURE)
NONE KNOWN
=================================================================
EMERGENCY AND FIRST AID PROCEDURES
NOT REQUIRED UNDER NORMAL CONDITIONS OF USE
GOOD PRACTICE SUGGESTS:
FOR EYE CONTACT FLUSH WITH PLENTY OF WATER
FOR SKIN CONTACT WASH THOROUGHLY WITH SOAP
AND WATER.
INHALATION REMOVE TO FRESH AIR, RESTORE
BREATHING IF NECESSARY. 
 
 
SECTION 7 SPILL OR LEAK PROCEDURES PAGE 3 OF 4
 
STEPS TO BE TAKEN IN CASE THE MATERIAL IS RELEASED OR SPILLED:
CLEAN UP SPILL PROMPTLY, KEEP DOWNWIND FROM SPILL.
FOR SMALL SPILLS, ABSORB IN AN INERT MATERIAL.
(CLAY, SAND, DIRT, ETC.)
FOR LARGE SPILLS, CONTAIN WITH ABSORBENT MATERIAL AND 
 
 
 
=================================================================
 
SECTION 8 RECOMMENDED CONTROL MEASURES
 
RESPIRATION PROTECTION USE OF RESPIRATION EQUIPMENT IS NECESSARY
IF CONCENTRATION EXCEEDS EXPOSURE LIMITS.
 
VENTILATION USE ADEQUATE VENTILATION TO KEEP VAPORS
BELOW EXPOSURE LIMITS.
 
PROTECTIVE GLOVES NEOPRENE OR IMPERVIOUS
 
EYE PROTECTION APPROVED EYE PROTECTION REQUIRED
 
OTHER PROTECTIVE EQUIPMENT
A SOURCE OF CLEAN FRESH WATER SHOULD BE
AVAILABLE FOR FLUSHING EYES OR SKIN.
IMPERVIOUS CLOTHING SHOULD BE WORN AS 
NEEDED.
=================================================================
 
SECTION 9 SPECIAL PRECAUTIONS
 
PRECAUTIONS TO BE TAKEN IN HANDLING OR STORAGE
WHERE SPLASH CAN OCCUR, USE CHEMICAL GOGGLES OR FULL FACE
SHIELD.
STORE IN A COOL DRY PLACE, 40 TO 90 oF PREFERRED. 
STORE AWAY FROM STRONG OXIDIZING AGENTS.
DO NOT STORE NEAR FOOD OR FEED.
 
=================================================================
 
SECTION 10 TRANSPORTATION DATA
 
 
FLAMMABLE AEROSOL
------------------------------------------------------------------ 
 
SARA 8#/GALLON
VOC 6#/GALLON 
 
 
SECTION 11 PRECAUTIONARY LABELING PAGE 4 OF 4
 
FOR INDUSTRIAL USE ONLY
 
KEEP OUT OF REACH OF CHILDREN
 
SEE LITERATURE AND/OR CONTAINER FOR ADDITIONAL
INFORMATION
 
DO NOT INCINERATE EMPTY CONTAINER. 
 
CONTAINS METHANOL, A POISON. 
 
===================================================================
 
JUDGEMENT AS TO THE SUITABILITY OF INFORMATION HEREIN OF THE
PURCHASER'S PURPOSE ARE NECESSARILY THE PURCHASER'S RESPONSIBILITY. REASONABLE 
CARE HAS BEEN TAKEN IN THE
PREPARATION OF THIS INFORMATION, BUT EXTENDS NO WARRANTIES,
MAKES NO REPRESENTATIONS AS TO THE ACCURACY OR SUITABILITY
OF THIS INFORMATION FOR ANY OF THE PURCHASER'S USE OR FOR
CONSEQUENCES OF MISUSE.